Riders of Kawasaki’s big honking Vulcan 1700 cruiser line, both the Vaquero and Voyager, should head this recall notice from the NHTSA, as it affects 11,836 units built between February 2, 2009 and March 20, 2015.
The recall concerns an ignition wire that may chafe, due to contact with the fuel tank. This can result in a short-circuit and possible engine stall, which in-turn could lead to the rider losing control of the motorcycle and crashing.
The National Highway Traffic Safety Administration (NHTSA) has levied with Triumph Motorcycles with a $2.9 million civil penalty for violations of Safety Act reporting requirements and failure to fully respond to communications from NHTSA.
That sum includes a $1.4 million cash penalty that Triumph must pay to the NHTSA, as well as a $500,000 expenditure in order to meet a series of requirements to improve its safety practices. Triumph could have to pay an added $1 million in penalties should the company violate the consent order or if additional Safety Act violations emerge.
Another recall this week, this time affecting the 2015 Harley-Davidson Street 750 (manufactured May 12, 2014, to June 24, 2015) & Street 500 (manufactured January 20, 2014, to June 24, 2015) motorcycles.
According to the information provided to the NHTSA, 10,580 motorcycles have a faulty fuel pump, which has a poor seal at the fuel pump inlet.
Bad news for Honda CBR500R & CB500 owners, as American Honda is recalling 14,575 units of the two motorcycle that were built for the 2013-2015 model years.
The recall comes about because of a fuel-level sensor float arm that can become deformed, due to exposure to “environmental and roadway conditions.” This deformation can cause the float arm to separate from the fuel level sensor body.
If the float arm separates from the sensor body, it can give the fuel meter inaccurate information, or in some cases the float may contact the positive and negative terminals, which would cause an electrical short.
American Honda is recalling a slew of motorcycles for a faulty starter relay switch. The recall affects over 45,000 units made between 2013 and 2016. The affected models are the CB500, CBR500, CRF250L, CBR650, CTX700, NSS300, VT750, VT1300, 2015 CB300F, CBR300, CBR600, and NC700.
On the affected motorcycles, a sealant may have been incorrectly applied to the starter relay switch, and as a result the electrical system can suffer from a loss of power. This can cause the engine to stall, and the motorcycle to crash, so a recall is in order.
Harley-Davidson has another massive recall on its hands, as the Bar & Shield has a bevy of models who are affect by saddlebag mountis that may not adequately secure the saddlebags to the motorcycle.
The recall affects certain model year 2014-2015 Road King (FLHR), Street Glide (FLHX), Street Glide Special (FLHXS), Electra Glide Ultra Classic (FLHTCU), Ultra Limited (FLHTK), Police Road King (FLHP), Police Electra Glide (FLHTP), CVO Ultra Limited (FLHTKSE), 2014 CVO Road King (FLHRSE), and 2015 Electra Glide Ultra Classic Low (FLHTCUL), Ultra Limited Low (FLHTKL), Road Glide (FLTRX), Road Glide Special (FLTRXS), CVO Street Glide (FLHXSE), and CVO Road Glide Ultra (FLTRUSE) motorcycles.
Say that three times fast.
Attention 2014 KTM 1290 Super Duke R owner, KTM North America is recalling 640 units of “The Beast” for a fuel leak that may occur from the threaded inserts at the rear of the gas tank.
Obviously, a fuel tank poses a safety hazard to the rider, not only for its propensity to combust, but its ability to degrade traction to the rear tire. As such, KTM will notify affected owners, and KTM dealers will seal the threaded inserts to prevent future fuel leaks.
If you are the owner of a 2008-2011 Yamaha WR250X or 2008-2015 WR250R dirt bike, this recall might concern you. Affecting 12,721 units in total, Yamaha is recalling its WR off-roaders because of the insulation on the starter coil, which may become damaged and short-circuit due to insufficient heat resistance.
The result of such a failure would result in the battery not getting charged, and thus ultimately dying. This can cause the engine to stall, which in-turn can be a safety concern for the rider.
More trouble for Öhlins suspension owners, as Öhlins USA is recalling 50 units of its ?hlins RXF 48mm front forks for motocross bikes. The recall notice simply states that the forks can break or detach during using, which poses a crash hazard.
The effects of the Öhlins suspension recalls continue to amount, and to no one’s surprise it has finally come to affect the Italian superbikes of Ducati.
As such, Ducati North America is recalling certain 2014 model year Ducati 1199 Panigale S, Ducati Panigale R, and Ducati Superleggera motorcycles for faulty rear shocks.
Another bike is affected by the Öhlins suspension failure, as American Honda has submitted what it calls the Honda CBR1000S (that’s the CBR1000RR SP for everyone else) for recall with the NHTSA.
In total 504 units are affected by Honda’s recall, which applies to 2014 motorcycles made between December 9, 2013 and to March 28, 2014, and to 2015 motorcycles made between October 20, 2014 and February 27, 2015.